7.2V Cell Honda Civic Hybrid Battery / 02 03 Honda Civic Battery Good Performance

Hyno Energy. Hybrid Battery Pack Replacement For Honda Civic (1998-2005). 6500mAh 144V, Guaranteed performance

Ford has fared a little better on the durability front. Its failure rates are lower than other manufacturers and early results showed that there were only a handful of failures among the first 190,000 batteries built. Taxi fleets all over the country use Escape Hybrids and many are reaching 300,000 miles without any battery issues. Ford did have some issues with auxiliary components and ended up recalling the Motor Electronics Coolant (MEC) pump that cools the power electronics. The affected pumps could fail and cause the car to go into limp-home mode with reduced power.

Technical Specification

All specification refers to the original car battery:

Battery Module:

Voltage: 7.2 V

Capacity: 6.5 Ah

Length: 380mm

Net Weight: 1040g

The whole battery pack consisted by 20 set of above modules

Battery Pack:

Cautions of Battery Pack Transportation and Storage

1. Avoid violent vibration and external force impact, don’t cast, roll, invert, extrude, and stack too high during handling and transportation of battery pack.
2. Protect the battery pack from rain during the transportation, and the ambient temperature is not over 55℃.
3. Store the battery pack in a cool and dry place and the temperature range is 5-25℃ when you are not using it.

Maintenance regulations (Maintain the whole battery pack, and cool with a fan during the charge and discharge process)

The SOC of our battery pack is 60%~80% when leaving the factory, in long-term storage, battery should be stored in a charged state (usually the SOC is 80%). Have a charge and discharge maintenance to battery pack when the storage time is over 6 months or battery module’s voltage is 15V,to prevent the battery performance’s decline caused by the self-discharge. The maintenance regulations are as follows:

1. Discharge: 2A discharge to 204V (that is to say: single cell 1.0V)
2. Interval: 30 minutes
3. Charge: 1.3A charge for 5 hours (voltage ≥ 306V, -ΔV ≥ 0.2V and temperature ≥50℃)
4. Interval: 1hours
5. Discharge: 2A discharge to 204V (that is to say: single cell 1.0V)
6. Interval: 30 minutes
7. Charge: 2A charge for 2.4 hours

Installation Cautions of battery pack

Notes: Installing this product should only be attempted by a qualified technician, the voltage of the battery pack is very high, which has the shock hazards, so when installing the battery pack, you should wear insulating gloves and use insulated handle tools.

1. Please operate according to assembly manual during the installation of Prius battery pack.
2. Do not mix our battery modules with those of other manufacturers, or new battery modules in use with semi-used battery modules, and don’t mix battery modules within a battery pack with those in other battery pack.
3. Don’t twist and bend battery modules and accessories when assembling battery pack.
4. Don’t connect the anode and cathode of battery module in reverse when assembling battery pack, to prevent short circuits.
5. Fasten bolts and nuts with appropriate torque, avoid loose connection or damaging other accessories with too big torque.